HVAC Service in Valley Station, KY

A gas-heat, mid-century neighborhood on the river side of the county

Valley Station runs along Dixie Highway in southwest Jefferson County, with the
Ohio River as its western edge. Most of the housing here went up in the decades after
the war, and the neighborhood grew with the Dixie Highway corridor once the road was
widened in the 1960s. The result is a large stock of single-family ranches and
split-levels, most of them now on their third or fourth heating system.

It is also overwhelmingly a natural gas neighborhood. Roughly 86 percent of homes
here heat with utility gas and about 13 percent with electricity. In practice, that
means the typical Valley Station system is a gas furnace paired with a split-system
air conditioner, and most of our calls here are about one or the other.

What is different about HVAC work in Valley Station

River bottomland and moisture

Much of Valley Station is low, flat ground between the river and the knobs. The
floodwall and the Pond Creek pumping station keep the river out, but the ground stays
damp, and that shows up in homes built over crawlspaces. A humid crawlspace does three
things to an HVAC system: supply ducts running through it sweat in summer, metal
components corrode faster, and a high-efficiency furnace’s condensate line can freeze
where it runs through unheated space in a January cold snap.

None of that is exotic, but a contractor who does not look under the house will
miss it. We check crawlspace duct runs and insulation on every system evaluation here.

Condensers in low, flat yards

On flat lots, the outdoor unit often sits where water collects after a heavy rain.
A condenser pad that has settled into a low spot keeps the base pan and bottom of the
coil wet, which accelerates corrosion and can let water reach the electrical
connections. Re-leveling or raising the pad is a small job that protects an expensive
piece of equipment.

If your outdoor unit or furnace has ever actually been under water, do not run it
until it has been inspected. Gas valves and control boards that have been submerged
need to be replaced, not dried out. That is a safety rule, not an upsell.

Humidity is the summer problem, not heat

River-valley summers are humid, and humidity is what exposes an oversized air
conditioner. It cools the house fast, shuts off before it has pulled moisture out of
the air, and leaves rooms that read 72 degrees on the thermostat and still feel
clammy. When we quote a replacement in Valley Station we size it with a load
calculation rather than matching the old unit’s tonnage, because the old unit was
often oversized to begin with.

Heat pumps in a gas neighborhood

With gas already at the house, a furnace is usually the straightforward
replacement. But the 13 percent of Valley Station homes on electric heat are often
running aging electric furnaces or first-generation heat pumps, and for those homes a
modern heat pump is a genuine operating-cost improvement. For gas homes replacing the
air conditioner anyway, a heat pump paired with the existing furnace (a dual-fuel
setup) is worth pricing. We will show you both numbers.

Permits

Valley Station is inside Louisville Metro, so furnace, air conditioner, and heat
pump replacements are permitted and inspected through Metro. We pull the permit on
every replacement. If a quote does not include one, ask why.

HVAC services we provide in Valley Station

• Furnace repair in Valley Station
• Air conditioner repair and replacement
• Heat pump installation, including dual-fuel systems
• Ductwork repair and crawlspace duct sealing
• Dehumidifiers for damp crawlspaces and basements
• Furnace tune-ups and the Pro Saver Club maintenance plan
• Emergency heating service

Useful reading for Valley Station homeowners

• How to size a furnace: Manual J and why bigger is not better
• Carbon monoxide and your furnace: warning signs and safe response

Getting to you

We are based on Holsclaw Hill Road in Fairdale, on the other side of Jefferson
Memorial Forest. Valley Station is part of our home territory in the southwest corner
of the county, not a far-flung service area.

Nearby areas we serve

From Valley Station we also cover
Orell to the south,
Pleasure Ridge Park,
Shively up Dixie Highway,
and our home base in Fairdale,
along with the rest of Louisville and surrounding communities.